filename: tfs 107c.doc version 1.5 07.07.2006 vi telefilter filter specification tfs 107c 1/5 measurement condition ambient temperature: 25 c input pow er level: 0 dbm terminating impedance: * input: 323 ? || -10,5 pf output: 162 ? || -17,9 pf ch aracteristics remark: the reference lev e l for the relativ e attenuation a rel of the tfs 107c is the mini mum of the pass band attenuation a min . the minimum of the pass band attenuation a min is defined as the insertion loss a e . the centre frequency f c is the arithmetic mean v a lue of the upper and low e r frequencies at the 3 db filter attenuation lev e l relativ e to the insertion loss a e . the nominal frequency f n is fix ed at 107,2 mhz w i thout any tole rance. the giv en v a lues for both the relativ e attenuation a rel and the group delay ripple hav e to be achiev ed at the frequencies giv en below ev en if the centre frequency f c is shifted due to the temperature coefficient of frequency tc f in the operating temperature range and due to a production tolerance for the centre frequency f c . d a t a ty p. v a lue tolerance / limit insertion loss a e 1 6 , 2 d b m a x . 2 0 , 0 d b (reference level) nominal frequency f n - 1 0 7 , 2 5 m h z centre frequency f c ** 107,25 mhz max. 100 khz passband pb - f c 23,5 mhz pass band ripple (p-p) 0 , 7 d b m a x . 1 , 0 d b bandw idth b w 1 d b 4 9 m h z m i n . 4 7 , 0 m h z relativ e attenuation a rel f c ? f c 2 3 , 5 mhz 0 , 7 d b m a x . 1 d b f c - 1 0 0 m h z ? f c - 3 0 , 9 mhz 4 3 d b m i n . 4 0 d b f c + 3 0 , 9 m h z ? f c + 4 0 0 mhz 4 3 d b m i n . 4 0 d b group delay ripple w i thin pb (p-p) 6 5 n s m a x . 2 0 0 n s operating temperature range otr - - 25 c ... + 80c storage temperature range - - 40 c ... + 85c temperature coefficient of frequency t c f *** -90 ppm/k *) the terminating impedances depend on paras itics and q-v a lues of matching element s and the board used, and are to be understo od as reference v a lues only . should there be additional questi ons do not hesitate to ask for an applicat ion note or contact our design team. **) at 30c ***) ? f c (hz) = tc f (ppm/k) x (t - t a ) x f cat (m h z ) ge ne ra te d: ch ecked / a p p r o v ed : tele filter gmbh potsdamer stra?e 18 d 14 513 teltow / germany tel: (+49) 3328 4784-0 / fax: (+49) 3328 4784-30 e-mail: tft@telefilter.co m vi telefilter reserves the right to make changes to the produc t(s) and/or information contained herein w i thout notice. no liab ility is assumed as a result of their use or application. no rights under any patent accompany the sale of any such product(s) or infor mation.
filename: tfs 107c.doc version 1.5 07.07.2006 vi telefilter filter specification tfs 107c 2/5 f ilter ch aracteristic 32. 2 47. 2 62 . 2 77 . 2 92 . 2 10 7. 2 122 . 2 137 . 2 152 . 2 1 67. 2 18 2. 2 -6 0 -5 4 -4 8 -4 2 -3 6 -3 0 -2 4 -1 8 -1 2 -6 0 f r e q uency i n m h z m a gni t ude i n db 81. 2 86. 4 91 . 6 96 . 8 102 107 . 2 11 2. 4 11 7. 6 12 2. 8 128 1 33. 2 -1 0 -9 -8 -7 -6 -5 -4 -3 -2 -1 0 f r equency i n m h z m a gni t ude i n db 81. 2 86. 4 91 . 6 96 . 8 102 107 . 2 11 2. 4 11 7. 6 12 2. 8 128 1 33. 2 0. 4 7 0. 6 2 0. 7 7 0. 9 2 1. 0 7 1. 2 2 1. 3 7 1. 5 2 1. 6 7 1. 8 2 1. 9 7 f r equency i n m h z d e la y in s cons truc tion a nd pin c onne c t ion (all dimensions in mm) 9, 3 ma x . 5, 0 m a x . 1 2 3 4 5 6 7 8 9 10 1, 8 m a x . 7, 1 2, 54 0, 1 0, 1 0 0, 8 2, 8 2, 54 0,1 2, 5 4 0 , 1 6 0 1 2 3 4 5 6 7 8 9 10 d a te c o d e date code: y ear + w eek u 2006 v 2007 w 2008 ... 1 ground 2 ground 3 ground 4 output 5 output rf return 6 ground 7 ground 8 ground 9 input 10 input rf return tfs 107c u27 50 oh m t est circu i t 1, 2, 3, 6, 7, 8 c1 l1 sa w l 2 c2 10 5 4 9 tele filter gmbh potsdamer stra?e 18 d 14 513 teltow / germany tel: (+49) 3328 4784-0 / fax: (+49) 3328 4784-30 e-mail: tft@telefilter.co m vi telefilter reserves the right to make changes to the produc t(s) and/or information contained herein w i thout notice. no liab ility is assumed as a result of their use or application. no rights under any patent accompany the sale of any such product(s) or infor mation.
filename: tfs 107c.doc version 1.5 07.07.2006 vi telefilter filter specification tfs 107c 3/5 stability characteristics, reliability after the follow i ng tests the filter shall meet the w hole specification: 1. shock: 500g, 1 ms, half sine w a ve, 3 shocks each plane; din iec 68 t2 - 27 2. vibration: 10 hz to 500 hz, 0,35 mm or 5 g respecti vely , 1 octave per min, 10 cy cles per plan, 3 plans; din iec 68 t2 - 6 3. change of temperature: -55 c to 125c / 30 min. each / 10 cy cles din iec 68 part 2 ? 14 test n 4. resistance to solder heat (reflow ): reflow possible: tw ice max.; for temperature conditions refer to the attac hed "air reflow temperature conditions" on page 4; this filter is rohs compliant (2002/95/eg, 2005/618/eg) packin g tape & reel: iec 286 ? 3, w i th exception of value for n and minimum bending radius; tape ty pe ii, embossed carrier tape w i th top cover tape on the upper side; max. pieces of filters per reel: 3000 reel of empty components at start: min. 300 mm reel of empty components at start including leader: min. 500 mm trailer: min. 300 mm g do w ct f e g d1 p2 p1 po bo ao p u l l o ff di r e c t io n pi n m a r k e r ty p da t e c o d e ko t tape (al l di mensi ons i n mm) w : 16,00 0,3 po : 4,00 0,1 do : 1,50 +0,1/-0 e : 1,75 0,1 f : 7,50 0,1 g(min) : 0,60 p2 : 2,00 0,1 p1 : 8,00 0,1 d1(min) : 1,50 a o : 5,30 0,1 bo : 9,70 0,1 ct : 13,5 0,1 a c n w 1 w 2 r eel (all d i men s io n s in mm) a : 330 w 1 : 16,4 +2/-0 w 2 (max ) : 22,4 n(min) : 50 c : 13,0 +0,5/-0,2 the minimum bending radius is 45 mm. tele filter gmbh potsdamer stra?e 18 d 14 513 teltow / germany tel: (+49) 3328 4784-0 / fax: (+49) 3328 4784-30 e-mail: tft@telefilter.co m vi telefilter reserves the right to make changes to the produc t(s) and/or information contained herein w i thout notice. no liab ility is assumed as a result of their use or application. no rights under any patent accompany the sale of any such product(s) or infor mation.
filename: tfs 107c.doc version 1.5 07.07.2006 vi telefilter filter specification tfs 107c 4/5 a i r re flow te mpe r a t ure c onditions conditions exposure average ramp-up rate (30c to 217c) less than 3c/second > 100c betw een 300 and 600 seconds > 150c betw een 240 and 500 seconds > 217c betw een 30 and 150 seconds peak temperature max. 260c time w i thin 5c of actual peak temperature betw een 10 and 30 seconds cool-dow n rate (peak to 50c) less than 6c/second time from 30c to peak temperature no greater than 300 seconds chip-mount air reflow profile temperature / c max. 260c 217c time / s max. 300 s 10 ... 30 s 30 ... 150 s tele filter gmbh potsdamer stra?e 18 d 14 513 teltow / germany tel: (+49) 3328 4784-0 / fax: (+49) 3328 4784-30 e-mail: tft@telefilter.co m vi telefilter reserves the right to make changes to the produc t(s) and/or information contained herein w i thout notice. no liab ility is assumed as a result of their use or application. no rights under any patent accompany the sale of any such product(s) or infor mation.
filename: tfs 107c.doc version 1.5 07.07.2006 vi telefilter filter specification tfs 107c 5/5 history version reason of changes name date 1.0 - generation of development s pecification strehl 06.03.2006 1.1 - terminating impedance, ty pical va lues and filter characteristic added ? (preliminary values) pfeiffer 11.04.2006 - matching configuration added - relative attenuation in upper stop band mofified 1.2 - centre frequency changed according customer requirements pfeiffer 24.04.2006 - terminating impedance c hanged (preliminary value) 1.3 - change from development specification to filter specification pfeiffer 02.05.2006 - relative attenuation in upper stop band corrected 1.4 - change of terminating impedance, ty pical val ues and filter characteristic pfeiffer 02.06.2006 1.5 - template of relative attenuation corrected pfeiffer 07.07.2006 tele filter gmbh potsdamer stra?e 18 d 14 513 teltow / germany tel: (+49) 3328 4784-0 / fax: (+49) 3328 4784-30 e-mail: tft@telefilter.co m vi telefilter reserves the right to make changes to the produc t(s) and/or information contained herein w i thout notice. no liab ility is assumed as a result of their use or application. no rights under any patent accompany the sale of any such product(s) or infor mation.
|
